Winnebago Revel Lithium Ion Battery Use Best Practices

The Revel Class B diesel motorhome by Winnebago allows you to travel down roads others might not even try! This off-road capable camper van is built on the 4WD version of the Mercedes-Benz Sprinter chassis with features such as a power lift platform bed that raises up to reveal a spacious gear garage, a cassette-style toilet to minimize weight, and many more innovations giving outdoor enthusiasts so many choices all while going off-road and off-grid. The Winnebago Revel is equipped with (2) 125-amp-hour Lithium ion batteries with a dedicated second alternator to charge the system to extend your off-grid use.

Revel Lithium Ad Photo

The Winnebago Revel’s 125AH Lithium Ion Batteries are the only Made in the USA battery management system. Some key features to this battery include:

  • 25% more capacity than the competition,
  • Ability to crank engines
  • Reserve Capacity = 10% Reserve
  • High and low voltage cut off
  • High and low temperature control
  • Bluetooth Connectivity and App

Listed below you will find best practices maintaining your Winnebago Revel Lithium Ion Batteries.

TURN BATTERIES ON:  The Xantrex battery switch is located above the back of the dinette on the wall. Flashing lights on the panel indicate that the batteries are charging. Depending on the state of the batteries, the lights will flash in different sequences. Rapid flashing indicates the battery is using reserve power and should be re-charged.

CHARGE BATTERY SYSTEM (Driving) – Do not turn the batteries off while vehicle is on. There is a one minute delay between starting the engine and the alternator engaging. The alternator will engage and charge the batteries when they are between 12.8v and 13.1v. The alternator stops charging once the house batteries have shown sustained voltage of 14.2v.

  • Shore power – Make sure the batteries are turned on and plug in to shore power to charge using the 30amp connection on the outside of the coach.
  • Solar – With the batteries on, ensure the solar disconnect switch is turned to the on position. This switch is located between the Xantrex battery switch and the Zamp solar controller on the wall behind the dinette. The 215w Zamp solar panel is a trickle charger to help keep batteries topped off.

DOWNLOAD THE LITHIONICS APP

Search in the App Store or Google Play store “Lithionics Battery Monitor” and download the free app. The batteries can be monitored through the app after being connected via Bluetooth.

INVERTER/CHARGER

The inverter disconnect switch must be turned on to allow the batteries to be charged through shore power. Generally, this switch should remain in the “on” position at all times. The disconnect switch is located on the rear most panel on the driver side in the back of the coach near the floor. To activate the inverter or to use the outlets or A/C, turn the inverter on at the panel located above the solar controller on the wall behind the dinette.

LOW POWER

When the batteries shut down due to low charge, they can be turned back on in “reserve” to operate the coach but should be recharged before they shut down again. Reserve is the last 10% of the batteries’ capacity. Running through the reserve power to shut down again is abusive to the batteries.

COLD WEATHER USE

  • Turning off – If the coach is going to be stored in cold weather, it’s best to have the system charged 50% or more.
  • Temperature of batteries – The batteries are equipped with heating blankets to warm them in cold temperatures. There’s a switch in the battery compartment to turn them on and off. Use this switch to control battery temperatures when in cold weather. The blankets are thermostatically controlled when on. The blankets start heating when the temperature sensor is 35°F and will turn off when it reaches 45°F. Below 0°F, batteries will not charge or discharge. Plug into shore power. Warm the batteries up manually (space heater, park in a heated building, etc). When the batteries warm above 0°F, the heating blankets will take over warming the batteries. Between 0 and 32°F the coach can be operated on battery power, but batteries will not take a charge. Use the heating blankets to warm the batteries above 32°F to resume charging.

Call a Lichtsinn RV sales consultant today to find out more about the Winnebago Revel and its Xantrex Smart Lithium Batteries. The true 4×4 Revel opens up a world of possibilities with off the grid capabilities and complete four-season comfort in the #CamperVanLife #VanLife revolution!

Winnebago Revels For Sale

Experience the Best® at Lichtsinn RV, the #1 Winnebago Dealer in North America for the last six consecutive years. Lichtsinn RV is located 1 mile north of Winnebago Industries in Forest City, IA and we proudly sell new Winnebago motorhomes and pre-owned RVs from various manufacturers. While at Lichtsinn RV, you can expect no delivery miles on new RVs, a complimentary half-day educational orientation of your RVexcellent guest reviews, an assigned support team from sales, parts, service and the business officesuperior accommodationsno-hassle pricing and competitive financing. See our extensive new and used inventory here.

Return to LichtsinnRV.com

Posts You May Like: 

Winnebago Revel OCCC, GVWR, GCWR and More

Winnebago Revel vs. Boldt Lithium Systems

Measurements in the 2021 Winnebago Revel

Winnebago’s Class B Diesel Lineup